集成電路企業含氟廢水深度處理示范工程分析
作者:盧永1,2， 汪林2， 張煒銘1,2， 黃如全2， 馮向文2， 張孝林1， 呂振華2（1.南京大學環境學院 污染控制與資源化研究國家重點實驗室，江蘇 南京 210023；2.江蘇南大環�？萍加邢薰� 國家環境保護有機化工廢水處理與資源化工程技術中心，江蘇 南京 210046）
[1]盧永,汪林,張煒銘,等.集成電路企業含氟廢水深度處理示范工程分析[J].中國給水排水,2023,39(12):141-144.
LUYong,WANGLin,ZHANGWei-ming,et al.Analysis on a Demonstration Project of Advanced Treatment of Fluoride Wastewater from Integrated Circuit Enterprises[J].China Water & Wastewater,2023,39(12):141-144.點擊復制
集成電路企業含氟廢水深度處理示范工程分析
中國給水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第39卷 期數: 2023年第12期 頁碼: 141-144 欄目: 出版日期: 2023-06-17
Title:Analysis on a Demonstration Project of Advanced Treatment of Fluoride Wastewater from Integrated Circuit Enterprises
作者:盧永1,2， 汪林2， 張煒銘1,2， 黃如全2， 馮向文2， 張孝林1， 呂振華2（1.南京大學環境學院 污染控制與資源化研究國家重點實驗室，江蘇 南京 210023；2.江蘇南大環�？萍加邢薰� 國家環境保護有機化工廢水處理與資源化工程技術中心，江蘇 南京 210046）
Author(s):LU Yong1，2， WANG Lin2， ZHANG Wei-ming1，2， HUANG Ru-quan2， FENG Xiang-wen2， ZHANG Xiao-lin1， Lü Zhen-hua2（1. State Key Laboratory of Pollution Control and Resource Reuse， School of Environment， Nanjing University， Nanjing 210023， China； 2. State Environmental Protection Engineering Center for Organic Chemical Industrial Wastewater Disposal and Resource Reuse， Jiangsu NJU Environmental Technology Co. Ltd.， Nanjing 210046， China）
關鍵詞:集成電路; 含氟廢水; 深度處理; 化學沉淀; 納米材料吸附
Keywords:integrated circuit; fluoride wastewater; advanced treatment; chemical precipitation; nano?material adsorption
摘要:集成電路行業生產過程中會產生大量含氟廢水，隨著氟排放標準逐漸提高，采用傳統沉淀法已難以滿足需求。針對南京市某工業園區污水處理廠集成電路含氟廢水，示范項目采用“混凝沉淀-納米材料吸附”組合工藝進行處理，處理規模為1 000 m3/d。三個月的運行結果表明，進水氟濃度為4～5.5 mg/L，出水氟濃度穩定達到1 mg/L以下。該項目直接投資約550萬元，廢水處理成本約1.966 元/m3。
Abstract:A large amount of fluoride wastewater is produced in the process of integrated circuit industry. With a gradual improvement of fluoride discharge standard, it is difficult to meet the requirement by using traditional precipitation methods. A combined process of coagulation sedimentation and nano-material adsorption is adopted to treat the integrated circuit wastewater from an industrial park wastewater treatment plant in Nanjing. The project scale is 1 000 m3/d and the influent fluoride concentration is 4-5.5 mg/L. Within three months, the effluent fluoride concentration remained below 1 mg/L. The investment of the demonstration project is about 5.5 million yuan, and the total cost of wastewater treatment is about 1.966 yuan/m3.
更新日期/Last Update: 2023-06-17
中國給水排水雜志社官方網所有資料均源于網上的共享資源及期刊共享，請?zhí)貏e注意勿做其他非法用途 如有侵犯您的版權或其他有損您利益的行為，請聯系指出，本網會立即進行改正或刪除有關內容
論文發表投稿郵箱：cnwater@vip.163.com
CopyRight (C)2016 中國給水排水雜志社官方網 版權所有 津ICP備20004590號
[1]盧永,汪林,張煒銘,等.集成電路企業含氟廢水深度處理示范工程分析[J].中國給水排水,2023,39(12):141-144.
LUYong,WANGLin,ZHANGWei-ming,et al.Analysis on a Demonstration Project of Advanced Treatment of Fluoride Wastewater from Integrated Circuit Enterprises[J].China Water & Wastewater,2023,39(12):141-144.
點擊復制
LUYong,WANGLin,ZHANGWei-ming,et al.Analysis on a Demonstration Project of Advanced Treatment of Fluoride Wastewater from Integrated Circuit Enterprises[J].China Water & Wastewater,2023,39(12):141-144.
集成電路企業含氟廢水深度處理示范工程分析
中國給水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第39卷 期數: 2023年第12期 頁碼: 141-144 欄目: 出版日期: 2023-06-17
- Title:
- Analysis on a Demonstration Project of Advanced Treatment of Fluoride Wastewater from Integrated Circuit Enterprises
- Keywords:
- integrated circuit; fluoride wastewater; advanced treatment; chemical precipitation; nano?material adsorption
- 摘要:
- 集成電路行業生產過程中會產生大量含氟廢水，隨著氟排放標準逐漸提高，采用傳統沉淀法已難以滿足需求。針對南京市某工業園區污水處理廠集成電路含氟廢水，示范項目采用“混凝沉淀-納米材料吸附”組合工藝進行處理，處理規模為1 000 m3/d。三個月的運行結果表明，進水氟濃度為4～5.5 mg/L，出水氟濃度穩定達到1 mg/L以下。該項目直接投資約550萬元，廢水處理成本約1.966 元/m3。
- Abstract:
- A large amount of fluoride wastewater is produced in the process of integrated circuit industry. With a gradual improvement of fluoride discharge standard, it is difficult to meet the requirement by using traditional precipitation methods. A combined process of coagulation sedimentation and nano-material adsorption is adopted to treat the integrated circuit wastewater from an industrial park wastewater treatment plant in Nanjing. The project scale is 1 000 m3/d and the influent fluoride concentration is 4-5.5 mg/L. Within three months, the effluent fluoride concentration remained below 1 mg/L. The investment of the demonstration project is about 5.5 million yuan, and the total cost of wastewater treatment is about 1.966 yuan/m3.
更新日期/Last Update: 2023-06-17
