- 氧化—絮凝調理對剩余污泥脫水性能的影響
- Effects of oxidation-flocculation conditioning on dewatering performance of activated sludge
- 夏加華， 饒汀， 季娟， 劉安康， 梁炎凱， 孫永軍
- 土木與環境工程學報 2023年45卷第3期 頁碼：173-182
- DOI：10.11835/j.issn.2096-6717.2022.099 中圖分類號：X703.1
-
紙質出版日期：2023-06-25，
收稿日期：2022-08-01
-
引用本文
閱讀全文PDF
掃 描 看 全 文
摘要
針對污水處理廠污泥脫水難度大、運行成本高等問題，深入研究NaClO投加量、污泥混合液pH值以及在NaClO最佳投加量和污泥混合液最佳pH值下耦合聚合硫酸鐵（PFS）和三氯化鐵（FeCl3）對污泥脫水性能的影響，以期獲得氧化—絮凝調理對活性污泥脫水性能的影響機制。結果表明，在NaClO投加量為40 mg/g DS（絕干污泥）和污泥混合液pH值為3時，PFS耦合NaClO調理后的泥餅含水率和污泥比阻（Specific Cake Resistance，SRF）分別降至85.86%和4.74×1011 m/kg；FeCl3耦合NaClO調理后的泥餅含水率和污泥比阻分別降至86.36%和3.93×1011 m/kg。調理后的污泥絮體粒徑D50的大小關系為：NaClO+PFS>NaClO+FeCl3>pH值>原泥>NaClO。顯然，經過氧化—絮凝調理后的污泥絮體粒徑明顯增大，濾液中的有機質含量降低。氧化—絮凝調理可使活性污泥比阻顯著降低，脫水性能顯著改善。NaClO耦合PFS和NaClO耦合FeCl3有望成為高效環保、價格低廉的新型污泥脫水調理劑。
Abstract
In view of the difficulty of sludge dewatering and high operating cost in wastewater treatment plants, the effect of NaClO dosage, pH value of the sludge mixture, and the coupling of polymerized ferric sulfate (PFS)/ ferric chloride (FeCl3) under the optimal dosage of NaClO and the optimum pH value of the sludge mixture on the dewatering performance of sludge were studied in depth, in order to obtain the influence mechanism of oxidation-flocculation conditioning on the dewatering performance of activated sludge. The results showed that when the dosage of NaClO was 40 mg/g DS and pH value of the sludge mixture was 3, the moisture content of mud cake and sludge specific resistance (SRF) after PFS coupled NaClO conditioning were reduced to 85.86% and 4.74×1011 m/kg, respectively. The moisture content and sludge specific resistance of the mud cake after FeCl3 coupling NaClO conditioning were reduced to 86.36% and 3.93×1011 m/kg, respectively. The relationship of the conditioned sludge floc size D50 is: NaClO+PFS>NaClO+FeCl3>pH value >raw sludge>NaClO. Obviously, after oxidation-flocculation conditioning, the particle size of the sludge flocs increased significantly, and the organic matter content in the filtrate decreased. Oxidation-flocculation conditioning can significantly reduce SRF and improve the dewatering performance. NaClO coupled PFS and NaClO coupled FeCl3 are expected to be novel sludge dewatering conditioners with high efficiency, environmental protection and low price.
參考文獻
熊子康, 鄭懷禮, 尚娟芳, 等. 污水反硝化脫氮工藝中外加碳源研究進展[J]. 土木與環境工程學報(中英文), 2021, 43(2): 168-181.[百度學術]
XIONG Z K, ZHENG H L, SHANG J F, et al. State-of-the art review of adding extra carbon sources to denitrification of wastewater treatment [J]. Journal of Civil and Environmental Engineering, 2021, 43(2): 168-181. (in Chinese)[百度學術]
LIN W, LIU X, DING A, et al. Advanced oxidation processes (AOPs)-based sludge conditioning for enhanced sludge dewatering and micropollutants removal: A critical review [J]. Journal of Water Process Engineering, 2022, 45: 102468.[百度學術]
TOUTIAN V, BARJENBRUCH M, LODERER C, et al. Impact of process parameters of thermal alkaline pretreatment on biogas yield and dewaterability of waste activated sludge [J]. Water Research, 2021, 202: 117465.[百度學術]
WEI H, GAO B Q, REN J, et al. Coagulation/flocculation in dewatering of sludge: A review [J]. Water Research, 2018, 143: 608-631.[百度學術]
CAO B D, ZHANG T, ZHANG W J, et al. Enhanced technology based for sewage sludge deep dewatering: A critical review [J]. Water Research, 2021, 189: 116650.[百度學術]
徐文迪, 何茜, 常沙, 等. 基于Fe3+/EDTA-2Na的類芬頓對剩余污泥脫水性能的影響[J]. 環境科學研究, 2022, 35(6): 1475-1481.[百度學術]
XU W D, HE X, CHANG S, et al. Effect of Fenton-like sludge conditioner on waste activated sludge dewatering performance based on Fe3+/EDTA-2Na [J]. Research of Environmental Sciences, 2022, 35(6): 1475-1481. (in Chinese)[百度學術]
黃錦佳, 梁嘉林, 楊賢, 等. 超聲-生物瀝浸-氧化鈣聯合超高壓壓濾系統實現市政污泥深度脫水及其泥餅的毒性評估[J]. 環境科學學報, 2020, 40(5): 1745-1759.[百度學術]
HUANG J J, LIANG J L, YANG X, et al. Deep dewatering of sewage sludge by ultrasonic-bioleaching-lime conditioning combined with ultrahigh pressure filtration system and its toxicity evaluation [J]. Acta Scientiae Circumstantiae, 2020, 40(5): 1745-1759. (in Chinese)[百度學術]
羅璐, 施周, 周先敏, 等. 溶菌酶改善剩余污泥脫水性能的效果及影響因素研究[J]. 安全與環境學報, 2022, 22(2): 1006-1013.[百度學術]
LOU L, SHI Z, ZHOU X M, et al. Enhancement of activated sludge dewatering performance by lysozym and its influencing factors [J]. Journal of Safety and Environment, 2022, 22(2): 1006-1013. (in Chinese)[百度學術]
甄廣印, 吳太樸, 陸雪琴, 等. 高級氧化污泥深度脫水技術研究進展[J]. 環境污染與防治, 2019, 41(9): 1108-1113, 1119.[百度學術]
ZHEN G Y, WU T P, LU X Q, et al. A review on advanced oxidation processes for enhancing sewage sludge dewatering [J]. Environmental Pollution ＆ Control, 2019, 41(9): 1108-1113, 1119. (in Chinese)[百度學術]
城市污水處理廠污泥檢驗方法： CJ/T 221—2005 [S].北京：中國標準出版社，2006.[百度學術]
Determination method for municipal sludge in wastewater treatment plan: CT/T 221—2005 [S]. Beijing: Standards Press of China, 2006. (in Chinese)[百度學術]
趙曉琦, 王毅力, 張達鑫, 等. 活性污泥脫水性能與電化學阻抗譜參數的關聯特性[J]. 環境工程學報, 2022, 16(3): 954-961.[百度學術]
ZHAO X Q, WANG Y L, ZHANG D X, et al. Study on the correlation between dewatering performance of activated sludge and electrochemical impedance spectroscopy parameters [J]. Chinese Journal of Environmental Engineering, 2022, 16(3): 954-961. (in Chinese)[百度學術]
陸香玉, 俞海祥, 陳亞, 等. 化學絮凝與電絮凝調理污泥脫水性能影響作用的對比研究[J]. 環境科學學報, 2022, 42(3): 257-267.[百度學術]
LU X Y, YU H X, CHEN Y, et al. Comparison of the effects of chemical flocculation and electric flocculation conditioning on sludge dewatering performance [J]. Acta Scientiae Circumstantiae, 2022, 42(3): 257-267. (in Chinese)[百度學術]
孫文全, 朱輝, 孫永軍, 等. 響應面法優化光聚合CMCTS-g-CPAM及其污泥脫水性能[J]. 土木與環境工程學報(中英文), 2019, 41(4): 150-158.[百度學術]
SUN W Q, ZHU H, SUN Y J, et al. Optimization of photopolymerization CMCTS-g-CPAM by response surface methodology and evaluation of sludge dewatering performance [J]. Journal of Civil and Environmental Engineering, 2019, 41(4): 150-158. (in Chinese)[百度學術]
WU B R, DAI X H, CHAI X L. Critical review on dewatering of sewage sludge: Influential mechanism, conditioning technologies and implications to sludge re-utilizations [J]. Water Research, 2020, 180: 115912.[百度學術]
ZHENG H L, SUN Y J, GUO J S, et al. Characterization and evaluation of dewatering properties of PADB, a highly efficient cationic flocculant [J]. Industrial & Engineering Chemistry Research, 2014, 53(7): 2572-2582.[百度學術]
SUN W Q, ZHU H, SUN Y J, et al. Enhancement of waste-activated sludge dewaterability using combined Fenton pre-oxidation and flocculation process [J]. Desalination and Water Treatment, 2018, 126: 314-323.[百度學術]
王杰, 陳鈺, 趙玉婷, 等. 芬頓氧化鈣體系聯合DDBAC對污泥脫水性能的影響[J]. 環境工程學報, 2021, 15(4): 1424-1431.[百度學術]
WANG J, CHEN Y, ZHAO Y T, et al. Effect of Fenton's reagent and CaO system combined with DDBAC on sludge dewaterability [J]. Chinese Journal of Environmental Engineering, 2021, 15(4): 1424-1431. (in Chinese)[百度學術]
王偉云, 王詞稼, 徐鑫, 等. 氧化預處理對污泥蛋白質提取及脫水性的影響[J]. 安全與環境學報, 2021, 21(5): 2285-2292.[百度學術]
WANG W Y, WANG C J, XU X, et al. Effect of oxidation pretreatment on protein extraction and dewatering of sludge [J]. Journal of Safety and Environment, 2021, 21(5): 2285-2292. (in Chinese)[百度學術]
馮齊云, 高寶玉, 岳欽艷, 等. 不同陽離子聚丙烯酰胺有機脫水劑對污泥脫水性能的影響[J]. 環境科學, 2022, 43(2): 928-935.[百度學術]
FENG Q Y, GAO B Y, YUE Q Y, et al. Effect of different cationic polyacrylamide organic dehydrating agents on sludge dewatering performance [J]. Environmental Science, 2022, 43(2): 928-935. (in Chinese)[百度學術]
郭紹東, 李晨曦, 黃興虎, 等. 次氯酸鈉與亞鐵對污泥破解及脫水效果的影響[J]. 環境科學學報, 2021, 41(8): 3130-3137.[百度學術]
GUO S D, LI C X, HUANG X H, et al. Effects of sodium hypochlorite and ferrous iron on sludge disintegration and dewatering [J]. Acta Scientiae Circumstantiae, 2021, 41(8): 3130-3137. (in Chinese)[百度學術]
