WEIShang-hui,XUHeng,CHANGFeng-min,et al.Performance of Enhanced Membrane Coagulation for Rural Domestic Sewage Treatment and Its Sludge Resource Utilization Potential[J].China Water & Wastewater,2022,38(9):1-7.
農村生活污水強化膜混凝性能及其污泥資源化潛力
- Title:
- Performance of Enhanced Membrane Coagulation for Rural Domestic Sewage Treatment and Its Sludge Resource Utilization Potential
- 關鍵詞:
- 農村生活污水; 強化膜混凝; 污泥; 碳、磷回收; 酸堿預處理; 酸化發酵
- Keywords:
- rural domestic sewage; enhanced membrane coagulation; sludge; carbon and phosphorus recovery; acid/base pretreatment; acidified fermentation
摘要:- 農村生活污水和污泥的就地處理與資源化利用近年來受到廣泛關注，與生物法相比，強化膜混凝技術能快速捕獲污水中的碳、磷資源，目前已在北京農村地區的生活污水處理中得到示范應用。為此，分析了強化膜混凝技術的示范應用效果，并以其產生的污泥為研究對象，考察了污泥中碳、磷的回收性能。結果表明，強化膜混凝一體化示范設備能在水力停留時間為60 min的條件下實現80%以上COD和TP的去除，并產生富含碳、磷且具有較好資源化潛力的污泥。酸堿預處理能有效強化污泥水解，尤其是堿性條件能促進污泥中有機物和磷酸鹽的同步釋放，最高濃度分別達到5 214.5 mg/L和122 mg/L。酸化發酵是實現有機物進一步轉化利用的重要途徑之一，當污泥初始pH調為11時，酸化發酵效果最優，酸化產物產量達到3 419.6 mg/L（以COD計），酸化率高達77.0%。“強化膜混凝+污泥酸堿預處理+酸化發酵”有望促進農村生活污水中碳、磷資源的回收，但其后續利用方式和潛在風險需作進一步研究。
Abstract:- In recent years, the local treatment of rural domestic sewage and its sludge utilization has been widely concerned. Compared with biological processes, the enhanced membrane coagulation technology can rapidly capture carbon and phosphorus resources in sewage, and has been demonstrated in domestic sewage treatment in rural areas of Beijing. Therefore, performance of the demonstration project based on enhanced membrane coagulation technology was analyzed, and the recovery of carbon and phosphorus from the membrane coagulation sludge was investigated. The enhanced membrane coagulation integrated device removed more than 80% of COD and TP when the hydraulic retention time was 60 min, and produced sludge rich in carbon and phosphorus with good resource utilization potential. Acid/base pretreatment effectively enhanced the hydrolysis of sludge, promoted the simultaneous release of organic matter and phosphate from the sludge (especially in alkaline condition), and their highest concentrations were 5 214.5 mg/L and 122 mg/L, respectively. Acidified fermentation is one of the important ways to realize further conversion and utilization of organic matter. When the initial pH of the sludge was adjusted to 11, the best acidification fermentation performance was obtained: the acidification product yield reached 3 419.6 mg/L, and the acidification rate was up to 77.0%. The combined technology of enhanced membrane coagulation, acid/base pretreatment of sludge and acidified fermentation is expected to promote the recovery of carbon and phosphorus resources from rural domestic sewage. However, the subsequent utilization method and potential risks need to be further investigated.
相似文獻/References:
[1]謝冬冬,馮洪波,潘增銳,等.碳酸鈣和鐵碳復合填料去除農村生活污水中的磷[J].中國給水排水,2020,36(7):93.
[2]陳江杰,賀雷蕾,劉銳,等.A2O設施處理長三角平原地區農村生活污水的效果[J].中國給水排水,2020,36(9):75.
[3]陳娟,王超,王沛芳,等.基于人口分散度的農村生活污水處理模式選擇[J].中國給水排水,2020,36(23):81.
CHEN Juan,WANG Chao,WANG Pei-fang,et al.Choice of Rural Domestic Sewage Treatment Mode Based on Dispersion Degree of Rural Resident[J].China Water & Wastewater,2020,36(9):81.
[4]孔令為,邵衛偉,葉紅玉,等.農村生活污水治理技術應用的浙江經驗及發展方向[J].中國給水排水,2021,37(2):12.
KONG Ling-wei,SHAO Wei-wei,YE Hong-yu,et al.Experience and Development Direction of Application of Rural Domestic Wastewater Treatment Technology in Zhejiang Province[J].China Water & Wastewater,2021,37(9):12.
[5]羅憶涵,陳瑩,解舒婷,等.溫度、DO及C/N值對SBBR工藝脫氮除磷的影響[J].中國給水排水,2021,37(9):82.
LUO Yi-han,CHEN Ying,XIE Shu-ting,et al.Effects of Temperature, DO and C/N Ratio on Nitrogen and Phosphorus Removal in SBBR Process[J].China Water & Wastewater,2021,37(9):82.
