SARD與CSTR反應器半連續發酵產氫能力對比
- Title:
- Hydrogen Production Capacity of Semi continuous Fermentation of SARD and CSTR Bio hydrogen Production Reactor
- 文章編號:
- 1000-4602(2018)21-0007-06
- 作者:
- 劉常青1; 陳琬2; 曾藝芳3; 杜朝丹4; 陳美香4; 張燕瓊2; 鄭育毅2; 趙由才5
- (1. 福建師范大學地理科學學院，福建福州350007；2. 福建師范大學環境科學與工程學院，福建福州350007；3. 福建省環境保護設計院有限公司，福建福州350000；4. 福建海峽環保集團股份有限公司，福建福州350014；5. 同濟大學污染控制與資源化研究國家重點實驗室，200092)
- Author(s):
- LIU Chang qing1; CHEN Wan2; ZENG Yi fang3; DU Chao dan4; CHEN Mei xiang4; ZHANG Yan qiong2; ZHENG Yu yi2; ZHAO You cai5
- (1. School of Geographical Science, Fujian Normal University, Fuzhou 350007, China; 2. College of Environmental Science and Engineering, Fujian Normal University, Fuzhou 350007, China; ?3. Fujian Environmental Protection Design Institute Co. Ltd.Fuzhou 350000, China; 4. Fujian Haixia Environmental Protection Group Ltd.Fuzhou 350014, China; 5. State Key Laboratory of Pollution Control and Resource Reuse, Tongji University, Shanghai 200092, China)
- 關鍵詞:
- 污泥; 餐廚垃圾; 生物制氫; SARD反應器; CSTR反應器
- Keywords:
- sludge; food waste; bio-hydrogen production; semi-continuous anaerobic rotary drum; continuous stirred tank reactor
- 分類號:
- TU992
- 文獻標志碼:
- A
- 摘要:
- 污泥與餐廚垃圾含有豐富有機質，將其進行生物產氫具有處理固體廢棄物和開發氫能的雙重意義。生物反應器的高效啟動是該技術的關鍵因素。采用SARD和CSTR反應器并輔以血清瓶，以污泥和餐廚垃圾作為反應基質，考察不同運行時間、投配比(回流比)下的氫氣濃度及比產氫速率，以確定各反應器的最佳運行條件并篩選出較優的反應器。結果表明，SARD和CSTR在10~15 h內先后達到了50.34%和53.43%的氫氣濃度最大值，最大比產氫速率分別為18.09、?14.98 mL/?（gDS·h）。投配比為50%、進料時間間隔為8 h是較理想的進料方式。SARD與CSTR反應器半連續運行的比產氫速率在穩定階段分別維持在4.40、2.37 mL/（gDS·h）左右。相比較而言，SARD的運行效果優于CSTR，且半連續運行比批式運行的效果更佳。
- Abstract:
- Sludge and food wastes are rich in organic matter, and can be used as the substrate of bio?hydrogen production, which has a double significance for solid waste treatment and development of hydrogen energy. How to start the reactor efficiently is the key factors. SARD (semi?continuous anaerobic rotary drum) and CSTR(continuous stirred tank reactor) were used as hydrogen production reactor to investigate the influence of operation time and reflux ratio by adding sludge and food wastes, and analyzing hydrogen concentration and specific hydrogen yield. The results indicated that the hydrogen concentration reached the maximum value of 50.34% and 53.43% after 10-15 h in SARD and CSTR, respectively; the maximum specific hydrogen yield was 18.09 mL/(gDS·h) and 14.98 mL/(gDS·h) respectively. The better feeding mode was 50% adding ratio and interval 8 h. The specific hydrogen yields of SARD and CSTR were stable at 4.40 mL/(gDS·h）and 2.37 mL/(gDS·h) respectively. In comparison, semi?continuous operation was better than batch one, and SARD was better than CSTR.
參考文獻/References:
［1］盧文玉,劉銘輝,陳宇,等. 厭氧發酵法生物制氫的研究現狀和發展前景［J］. 中國生物工程雜志,2006,26(7):99-104.? Lu Wenyu,Liu Minghui,Chen Yu,?et al?. Research process of 〖JP〗anaerobic fermentative hydrogen production and its development future［J］. China Biotechnology,2006,26(7):99-104(in Chinese).
［2］任南琪,李永峰,李建政,等. 中國發酵法生物制氫技術研究進展［J］. 化工學報,2004,55(S1):7-14.? Ren Nanqi,Li Yongfeng,Li Jianzheng,?et al?. Progress of fermentative biohydrogen production process in China［J］. Journal of Chemical Industry and Engineering,2004,55(S1):7-14(in Chinese).?
［3］Liu X Y,Wang L,Li Y F,?et al?. The succession of microbial community in CSTR hydrogen production system［J］. Adv Mater Res,2010,113/116:1297-1301.?
［4］Dinamarca C,Bakke R. Process parameters affecting the sustainability of fermentative hydrogen production:Ashort?review［J］. International Journal of Energy Environment & Economics,2011,2(6):1067-1078.
［5］Han S K,Kim S H,Shin H S. UASB treatment of wastewater with VFA and alcohol generated during hydrogen fermentation of food waste［J］. Process Biochem,2005,40(8):2897-2905.
［6］Wang X,Ding J,Ren N Q,?et al?. CFD simulation of an expanded granular sludge bed (EGSB) reactor for biohydrogen production［J］. International Journal of Hydrogen Energy,2009,34(24):9686-9695.
［7］郭強. 餐廚垃圾滾筒式發酵制氫反應器設計及運行參數調控［D］. 上海:同濟大學,2007.? Guo Qiang. Design and Operation Parameters Regulation of Hydrogen Production of Food Wastes in SARD［D］. Shanghai:Tongji University,2007(in Chinese).
［8］Zhang Z P,Show K Y,Tay J H,?et al?. Effect of hydraulic retention time on biohydrogen production and anaerobic microbial community［J］. Process Biochem,2006,41
備注/Memo
基金項目：福建省科技廳重大專項(2015YZ0001-1)；福建省科技廳重點項目(2018Y0022)
通信作者：趙由才E-mail:zhaoyoucai@#edu.cn
作者簡介： 劉常青（1970- ），女，福建閩清人，博士，副教授，主要從事固體廢物處理與資源化研究。
E-mail:mylcq@126.com
收稿日期：2018-03-23
