PDF下載
[1]陳功.通溝污泥處理的提質增效改進工藝設計[J].中國給水排水,2021,37(16):78-82.
CHEN Gong.Process Design to Improve Quality and Efficiency of Sewer Sludge Treatment[J].China Water & Wastewater,2021,37(16):78-82.點擊復制
通溝污泥處理的提質增效改進工藝設計
中國給水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第37卷 期數: 2021年第16期 頁碼: 78-82 欄目: 出版日期: 2021-08-17
Title:Process Design to Improve Quality and Efficiency of Sewer Sludge Treatment
作者:陳功(同濟大學建筑設計研究院<集團>有限公司，上海200092)
Author(s):CHEN Gong(Tongji Architectural Design Co. Ltd.， Shanghai 200092, China)
關鍵詞:通溝污泥; 砂水分離; 工藝改進
Keywords:sewer sludge; sand-water separation; process improvement
摘要:針對常規通溝污泥處理工藝高負荷條件下洗砂效率下降、粒徑＜0.2 mm特細砂分離效率較低以及沖洗水消耗量高的問題，武漢市某通溝污泥處理工程采用兩級旋流+砂水分離的改進工藝，將通溝污泥分離成粒徑10 cm以上的大件物質、6 mm~10 cm的粗大物質、0.075~6 mm的無機砂、2~6 mm的有機渣等，其中0.075~6 mm的無機砂分離效率81.2%，0.075~0.1 mm特細砂分離效率73.4%，回用水利用率達73.1%，為區域性大型通溝污泥處理站的工程設計提供參考，有助于排水系統的提質增效。
Abstract:Conventional sewer sludge treatment process has the problems of low sand washing efficiency under high load conditions, lower separation efficiency of ultra-fine sand with a particle size of less than 0.2 mm and high washing water consumption. An improved process of two-stage cyclone and sand-water separation was employed in a sewer sludge treatment project in Wuhan, in which the sewer sludge was separated into large substances with particle size over 10 cm, coarse substances with particle size between 6 mm-10 cm, inorganic sand with particle size between 0.075-6 mm and organic residue with particle size between 2-6 mm, among which the separation efficiency of 0.075-6 mm inorganic sand was 81.2%, the separation efficiency of 0.075-0.1 mm ultrafine sand was 73.4%, and the reuse water utilization rate reached 73.1%. The result can provide a reference for engineering design of regional large-scale sewer sludge treatment station, and help to improve the quality and efficiency of the drainage system.
相似文獻/References:
[1]朱師杰,秦福軍,孔松,等.某市中心城區通溝污泥處置工藝運行現狀及建議[J].中國給水排水,2020,36(8):119.
[2]王繼行,盧偉,朱敏,等.通溝污泥處理工藝及其資源化利用研究[J].中國給水排水,2022,38(20):20.
WANGJi-hang,LUWei,ZHUMin,et al.Research on Sewer Sludge Treatment Process and Its Resource Utilization[J].China Water & Wastewater,2022,38(16):20.
[3]王君如,周傳庭.環境友好型通溝污泥處理工程實踐[J].中國給水排水,2023,39(10):85.
WANG Jun-ru,ZHOUChuan-ting.Practice of Environment-friendly Sewer Sludge Treatment Project[J].China Water & Wastewater,2023,39(16):85.
[4]關永年,徐超,陳勇.通溝污泥處理站改造實例[J].中國給水排水,2024,40(4):107.
GUANYong-nian,XUChao,CHENYong.Reconstruction Example of a Sewer Sludge Disposal Station[J].China Water & Wastewater,2024,40(16):107.
更新日期/Last Update: 2021-08-17
中國給水排水雜志社官方網所有資料均源于網上
[1]陳功.通溝污泥處理的提質增效改進工藝設計[J].中國給水排水,2021,37(16):78-82.
CHEN Gong.Process Design to Improve Quality and Efficiency of Sewer Sludge Treatment[J].China Water & Wastewater,2021,37(16):78-82.
點擊復制
CHEN Gong.Process Design to Improve Quality and Efficiency of Sewer Sludge Treatment[J].China Water & Wastewater,2021,37(16):78-82.
通溝污泥處理的提質增效改進工藝設計
中國給水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第37卷 期數: 2021年第16期 頁碼: 78-82 欄目: 出版日期: 2021-08-17
- Title:
- Process Design to Improve Quality and Efficiency of Sewer Sludge Treatment
- Keywords:
- sewer sludge; sand-water separation; process improvement
- 摘要:
- 針對常規通溝污泥處理工藝高負荷條件下洗砂效率下降、粒徑＜0.2 mm特細砂分離效率較低以及沖洗水消耗量高的問題，武漢市某通溝污泥處理工程采用兩級旋流+砂水分離的改進工藝，將通溝污泥分離成粒徑10 cm以上的大件物質、6 mm~10 cm的粗大物質、0.075~6 mm的無機砂、2~6 mm的有機渣等，其中0.075~6 mm的無機砂分離效率81.2%，0.075~0.1 mm特細砂分離效率73.4%，回用水利用率達73.1%，為區域性大型通溝污泥處理站的工程設計提供參考，有助于排水系統的提質增效。
- Abstract:
- Conventional sewer sludge treatment process has the problems of low sand washing efficiency under high load conditions, lower separation efficiency of ultra-fine sand with a particle size of less than 0.2 mm and high washing water consumption. An improved process of two-stage cyclone and sand-water separation was employed in a sewer sludge treatment project in Wuhan, in which the sewer sludge was separated into large substances with particle size over 10 cm, coarse substances with particle size between 6 mm-10 cm, inorganic sand with particle size between 0.075-6 mm and organic residue with particle size between 2-6 mm, among which the separation efficiency of 0.075-6 mm inorganic sand was 81.2%, the separation efficiency of 0.075-0.1 mm ultrafine sand was 73.4%, and the reuse water utilization rate reached 73.1%. The result can provide a reference for engineering design of regional large-scale sewer sludge treatment station, and help to improve the quality and efficiency of the drainage system.
相似文獻/References:
[1]朱師杰,秦福軍,孔松,等.某市中心城區通溝污泥處置工藝運行現狀及建議[J].中國給水排水,2020,36(8):119.
[2]王繼行,盧偉,朱敏,等.通溝污泥處理工藝及其資源化利用研究[J].中國給水排水,2022,38(20):20.
WANGJi-hang,LUWei,ZHUMin,et al.Research on Sewer Sludge Treatment Process and Its Resource Utilization[J].China Water & Wastewater,2022,38(16):20.
[3]王君如,周傳庭.環境友好型通溝污泥處理工程實踐[J].中國給水排水,2023,39(10):85.
WANG Jun-ru,ZHOUChuan-ting.Practice of Environment-friendly Sewer Sludge Treatment Project[J].China Water & Wastewater,2023,39(16):85.
[4]關永年,徐超,陳勇.通溝污泥處理站改造實例[J].中國給水排水,2024,40(4):107.
GUANYong-nian,XUChao,CHENYong.Reconstruction Example of a Sewer Sludge Disposal Station[J].China Water & Wastewater,2024,40(16):107.
更新日期/Last Update: 2021-08-17
