PDF下載
[1]王云飛,金錫標,朱國強,等.生物預處理工藝去除廢水中四環素類抗生素[J].中國給水排水,2023,39(1):86-90.
WANGYun-fei,JINXi-biao,ZHUGuo-qiang,et al.Biological Pretreatment Process for Removal of Tetracyclines Antibiotic from Wastewater[J].China Water & Wastewater,2023,39(1):86-90.點擊復制
生物預處理工藝去除廢水中四環素類抗生素
中國給水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第39卷 期數: 2023年第1期 頁碼: 86-90 欄目: 出版日期: 2023-01-01
Title:Biological Pretreatment Process for Removal of Tetracyclines Antibiotic from Wastewater
作者:王云飛， 金錫標， 朱國強， 王文琳（華東理工大學 資源與環境工程學院，上海 200237）
Author(s):WANG Yun-fei， JIN Xi-biao， ZHU Guo-qiang， WANG Wen-lin（School of Resources and Environmental Engineering， East China University of Science and Technology， Shanghai 200237， China）
關鍵詞:四環素類抗生素; 預處理; 生物曝氣; 混凝; 鐵鹽; 揮發性脂肪酸
Keywords:tetracyclines antibiotic; pretreatment; biological aeration; coagulation; iron salt; volatile fatty acid
摘要:針對四環素類抗生素（TCs）生產廢水在生物處理過程中普遍存在的泡沫劇烈、污泥沉降困難、處理效率低等問題，提出了生物曝氣—鐵鹽混凝預處理工藝。結果顯示，生物預處理工藝既可以提高TCs去除率，又能夠降低鐵鹽投加量，當鐵鹽投加量（以Fe計）為100 mg/L時，TCs去除率由27.5%提高到84.5%；對于未經生物預處理的廢水，若要達到相同的TCs去除效果，鐵鹽投加量為600 mg/L。這可能是由于廢水中77.8%的揮發性脂肪酸在生物預處理過程中被有效去除，從而降低了其對鐵鹽混凝去除TCs的干擾。經過生物預處理后，后續生物處理系統出水COD由531 mg/L降至199 mg/L，處理效果提升明顯。
Abstract:The biological treatment of tetracyclines (TCs) antibiotic production wastewater has the common problems such as large amount of foam, difficulty in sludge settlement and low treatment efficiency. To solve these problems, a pretreatment process consisting of biological aeration and iron salt coagulation was proposed. The biological pretreatment not only increased the TCs removal rate, but also reduced the dosage of iron salt. When the dosage of iron salt (calculated by Fe) was 100 mg/L, the TCs removal rate increased from 27.5% to 84.5%. To achieve the same TCs removal performance for wastewater without biological pretreatment, the dosage of iron salt was 600 mg/L. The reason might be due to the fact that 77.8% of volatile fatty acids in wastewater were effectively removed during the biological pretreatment process, thus reducing their interference to the removal of TCs by ferric coagulation. After the biological pretreatment, the COD in the effluent from the subsequent biological treatment system decreased from 531 mg/L to 199 mg/L, and the treatment performance was significantly improved.
相似文獻/References:
[1]張鋒,俞周,芮繼承,等.長距離輸水管道輸水過程中水質變化情況[J].中國給水排水,2022,38(15):50.
ZHANGFeng,YUZhou,RUIJi?cheng,et al.Changes of Water Quality in Long-distance Pipelines during Transmission[J].China Water & Wastewater,2022,38(1):50.
[2]賀棟才,楊婧,蔣彬,等.成都合作污水處理廠三期工程MP-MBR工藝設計[J].中國給水排水,2022,38(16):57.
HEDong-cai,YANGJing,JIANGBin,et al.MP-MBR Process Design of Chengdu Hezuo Wastewater Treatment Plant Phase Ⅲ Project[J].China Water & Wastewater,2022,38(1):57.
[3]王新,王玉慶,孫嘉欣,等.預處理+UASB+A/O組合工藝處理肝素鈉生產廢水[J].中國給水排水,2022,38(18):120.
WANGXin,WANGYu-qing,SUNJia-xin,et al.Treatment of Heparin Sodium Production Wastewater by Combined Process of Pretreatment, UASB and A/O[J].China Water & Wastewater,2022,38(1):120.
[4]王洋,黃奇云,謝杰,等.農村排水戶釀酒廢水收集、預處理和集中處理[J].中國給水排水,2022,38(22):123.
WANGYang,HUANGQi-yun,XIE Jie,et al.Collection, Pretreatment and Centralized Treatment of Brewing Wastewater in Rural Drainage Households[J].China Water & Wastewater,2022,38(1):123.
更新日期/Last Update: 2023-01-01
[1]王云飛,金錫標,朱國強,等.生物預處理工藝去除廢水中四環素類抗生素[J].中國給水排水,2023,39(1):86-90.
WANGYun-fei,JINXi-biao,ZHUGuo-qiang,et al.Biological Pretreatment Process for Removal of Tetracyclines Antibiotic from Wastewater[J].China Water & Wastewater,2023,39(1):86-90.
點擊復制
WANGYun-fei,JINXi-biao,ZHUGuo-qiang,et al.Biological Pretreatment Process for Removal of Tetracyclines Antibiotic from Wastewater[J].China Water & Wastewater,2023,39(1):86-90.
生物預處理工藝去除廢水中四環素類抗生素
中國給水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第39卷 期數: 2023年第1期 頁碼: 86-90 欄目: 出版日期: 2023-01-01
- Title:
- Biological Pretreatment Process for Removal of Tetracyclines Antibiotic from Wastewater
- 關鍵詞:
- 四環素類抗生素; 預處理; 生物曝氣; 混凝; 鐵鹽; 揮發性脂肪酸
- Keywords:
- tetracyclines antibiotic; pretreatment; biological aeration; coagulation; iron salt; volatile fatty acid
- 摘要:
- 針對四環素類抗生素（TCs）生產廢水在生物處理過程中普遍存在的泡沫劇烈、污泥沉降困難、處理效率低等問題，提出了生物曝氣—鐵鹽混凝預處理工藝。結果顯示，生物預處理工藝既可以提高TCs去除率，又能夠降低鐵鹽投加量，當鐵鹽投加量（以Fe計）為100 mg/L時，TCs去除率由27.5%提高到84.5%；對于未經生物預處理的廢水，若要達到相同的TCs去除效果，鐵鹽投加量為600 mg/L。這可能是由于廢水中77.8%的揮發性脂肪酸在生物預處理過程中被有效去除，從而降低了其對鐵鹽混凝去除TCs的干擾。經過生物預處理后，后續生物處理系統出水COD由531 mg/L降至199 mg/L，處理效果提升明顯。
- Abstract:
- The biological treatment of tetracyclines (TCs) antibiotic production wastewater has the common problems such as large amount of foam, difficulty in sludge settlement and low treatment efficiency. To solve these problems, a pretreatment process consisting of biological aeration and iron salt coagulation was proposed. The biological pretreatment not only increased the TCs removal rate, but also reduced the dosage of iron salt. When the dosage of iron salt (calculated by Fe) was 100 mg/L, the TCs removal rate increased from 27.5% to 84.5%. To achieve the same TCs removal performance for wastewater without biological pretreatment, the dosage of iron salt was 600 mg/L. The reason might be due to the fact that 77.8% of volatile fatty acids in wastewater were effectively removed during the biological pretreatment process, thus reducing their interference to the removal of TCs by ferric coagulation. After the biological pretreatment, the COD in the effluent from the subsequent biological treatment system decreased from 531 mg/L to 199 mg/L, and the treatment performance was significantly improved.
相似文獻/References:
[1]張鋒,俞周,芮繼承,等.長距離輸水管道輸水過程中水質變化情況[J].中國給水排水,2022,38(15):50.
ZHANGFeng,YUZhou,RUIJi?cheng,et al.Changes of Water Quality in Long-distance Pipelines during Transmission[J].China Water & Wastewater,2022,38(1):50.
[2]賀棟才,楊婧,蔣彬,等.成都合作污水處理廠三期工程MP-MBR工藝設計[J].中國給水排水,2022,38(16):57.
HEDong-cai,YANGJing,JIANGBin,et al.MP-MBR Process Design of Chengdu Hezuo Wastewater Treatment Plant Phase Ⅲ Project[J].China Water & Wastewater,2022,38(1):57.
[3]王新,王玉慶,孫嘉欣,等.預處理+UASB+A/O組合工藝處理肝素鈉生產廢水[J].中國給水排水,2022,38(18):120.
WANGXin,WANGYu-qing,SUNJia-xin,et al.Treatment of Heparin Sodium Production Wastewater by Combined Process of Pretreatment, UASB and A/O[J].China Water & Wastewater,2022,38(1):120.
[4]王洋,黃奇云,謝杰,等.農村排水戶釀酒廢水收集、預處理和集中處理[J].中國給水排水,2022,38(22):123.
WANGYang,HUANGQi-yun,XIE Jie,et al.Collection, Pretreatment and Centralized Treatment of Brewing Wastewater in Rural Drainage Households[J].China Water & Wastewater,2022,38(1):123.
更新日期/Last Update: 2023-01-01
