WANG Sheng-dong.A Case of Sludge Deep Dewatering in Laogang Landfill Leachate Emergency Treatment Project[J].China Water & Wastewater,2021,37(24):107-112.
老港垃圾滲濾液應急項目污泥深度脫水工程實例
- Title:
- A Case of Sludge Deep Dewatering in Laogang Landfill Leachate Emergency Treatment Project
- 關鍵詞:
- 垃圾滲濾液; 膜技術; 應急處理; 深度脫水; 板框壓濾
- Keywords:
- landfill leachate; membrane technology; emergency treatment; deep dewatering; plate and frame filter press
- 摘要:
- 垃圾滲濾液處理多采用膜工藝,采用膜法處理滲濾液，且將剩余污泥含水率降至60%以下，是滲濾液處理的難點之一。老港應急滲濾液處理工程通過生產性的實證，試驗了多種藥劑工況，得出了板框壓濾結合有機混凝劑的方法，可實現剩余污泥含水率降至60%以下,其中采用聚胺法運行費用最低，約為600~750元/t絕干泥。該方法解決了膜法處理滲濾液將剩余污泥含水率降至60%以下的難題，可在類似工程中推廣使用。
Abstract:- Membrane technology is widely used in landfill leachate treatment, however, it is difficult to reduce the moisture content of residual sludge to below 60%. It is realized by the method of plate and frame filter press combined with organic coagulant through productive demonstration at Laogang landfill leachate emergency treatment plant, after testing a variety of chemical conditions. Among them, the polyamine method has the lowest operation cost of about 600-750 yuan/tDS. This method solves the problem of reducing the moisture content of residual sludge to below 60% in membrane treatment of leachate and can be widely used in similar projects.
相似文獻/References:
[1]田黎黎,蔡斌,周俊,等.處理垃圾滲濾液的納濾膜元件損壞診斷及修復[J].中國給水排水,2018,34(21):104.
TIAN Li li,CAI Bin,ZHOU Jun,et al.Damage Diagnosis and Repair of Nanofiltration Membrane Element Treating Leachate[J].China Water & Wastewater,2018,34(24):104.
[2]劉建偉,康心悅,岳鵬,等.城市生活垃圾綜合處理廠滲濾液全量化處理工程設計[J].中國給水排水,2020,36(10):70.
[3]高波,張磊,郭修智.UASB+A/O+MBR+兩級RO處理垃圾焚燒發電廠滲濾液[J].中國給水排水,2021,37(4):67.
GAO Bo,ZHANG Lei,GUO Xiu-zhi.Process of UASB+A/O+MBR+Two-stage RO for the Treatment of Leachate from Waste Incineration Power Plant[J].China Water & Wastewater,2021,37(24):67.
[4]蔣寶軍,劉卓驛,郭昊程,等.TiO2、Cu2O和氧化石墨烯復合氧化垃圾滲濾液效能[J].中國給水排水,2021,37(5):86.
JIANG Bao-jun,LIU Zhuo-yi,GUO Hao-cheng,et al.Combined Oxidation Efficiency of Landfill Leachate by TiO2, Cu2O and Graphene Oxide[J].China Water & Wastewater,2021,37(24):86.
[5]高峻峰,胡曉玲,宋建陽,等.BBR+Fenton氧化+BAF組合工藝處理垃圾滲濾液[J].中國給水排水,2021,37(12):151.
GAO Jun-feng,HU Xiao-ling,SONG Jian-yang,et al.Case Study on Landfill Leachate Treatment by a Combined Process of BBR System, Fenton Oxidation, and BAF[J].China Water & Wastewater,2021,37(24):151.
[6]丁西明,康建邨,閔海華,等.垃圾分類對垃圾滲濾液處理領域的影響分析[J].中國給水排水,2021,37(18):42.
DING Xi-ming,KANG Jian-cun,MIN Hai-hua,et al.Analysis on the Impact of Waste Classification on Waste Leachate Treatment[J].China Water & Wastewater,2021,37(24):42.
[7]趙永志,高嚴,何文麗,等.不同納濾膜對垃圾滲濾液結垢離子去除效果分析[J].中國給水排水,2021,37(23):57.
ZHAO Yong-zhi,GAO Yan,HE Wen-li,et al.Effect of Different Nanofiltration Membranes on Removal of Scale-forming Ions from Landfill Leachate[J].China Water & Wastewater,2021,37(24):57.
[8]黨康飛,張佳歡,代鑫,等.Fenton+BAF工藝用于生活垃圾滲濾液深度處理改造[J].中國給水排水,2021,37(24):78.
DANG Kang-fei,ZHANG Jia-huan,DAI Xin,et al.Application of Fenton/BAF Process in Reconstruction of Advanced Treatment of Landfill Leachate[J].China Water & Wastewater,2021,37(24):78.
[9]張華,曹雪楓,黃健,等.鈣鎂對滲濾液處理中微生物電子傳遞體系的影響[J].中國給水排水,2022,38(11):25.
ZHANGHua,CAOXue-feng,HUANGJian,et al.Effect of Calcium and Magnesium Ions on Microbial Electron Transport System in Landfill Leachate Treatment[J].China Water & Wastewater,2022,38(24):25.
[10]馬東兵,岳崢,丁西明,等.兩級AO+內置式超濾+兩級納濾工藝處理垃圾滲濾液[J].中國給水排水,2022,38(18):78.
MADong-bing,YUEZheng,DINGXi-ming,et al.Application of Two-stage AO, Built-in Ultrafiltration and Two-stage Nanofiltration Process for the Treatment of Landfill Leachate[J].China Water & Wastewater,2022,38(24):78.
