[1]楊宇寧,桑軍強,秦冰,等.化工生化剩余污泥穩定化研究[J].中國給水排水,2022,38(11):104-108.
YANGYu-ning,SANGJun-qiang,QINBing,et al.Stabilization of Biochemical Excess Sludge from Chemical Wastewater Treatment Process[J].China Water & Wastewater,2022,38(11):104-108.
點擊復制
YANGYu-ning,SANGJun-qiang,QINBing,et al.Stabilization of Biochemical Excess Sludge from Chemical Wastewater Treatment Process[J].China Water & Wastewater,2022,38(11):104-108.
化工生化剩余污泥穩定化研究
中國給水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第38卷 期數: 2022年第11期 頁碼: 104-108 欄目: 出版日期: 2022-06-01
- Title:
- Stabilization of Biochemical Excess Sludge from Chemical Wastewater Treatment Process
- Keywords:
- chemical enterprises; biochemical excess sludge; stabilization; moisture content of mud cake
摘要:- 化工企業在生產過程中不可避免地產生大量生化剩余污泥，相較于市政剩余污泥，此類污泥含有更多的有機物，更加難處理。為此，
利用自主研發的剩余污泥穩定化處理技術，對華南某化工廠的生化剩余污泥開展工業側線試驗，取得了較好的效果。在穩定劑/MLVSS=0.70、反應溫度為175 ℃、反應時間為2 h的最佳處理?xiàng)l件下，化工生化剩余污泥的穩定化率可達到66%以上，減量率達到98.9%以上，泥餅含水率在60%以下；污泥脫水液pH呈中性，BOD5/COD在0.3以上，屬于易生化處理的污水，且該股水量較少，可直接送至污水廠進行處理。
Abstract:- Chemical enterprises inevitably produce a large amount of biochemical excess sludge in the production process. Compared with municipal excess sludge, this kind of sludge contains more organic matter and is more difficult to treat. Therefore, the industrial sidestream test of biochemical excess sludge from a chemical plant in South China was carried out and good results were obtained by using the self-developed excess sludge stabilization technology. Under the optimal treatment conditions as follows: stabilizer to MLVSS ratio of 0.70, reaction temperature of 175 ℃ and reaction time of 2 h, the stabilization rate of the excess sludge was more than 66%, the reduction rate was more than 98.9%, and the moisture content of the mud cake was less than 60%. The pH of sludge dewatering liquid was neutral, and BOD5/COD was above 0.3, indicating that the sludge dewatering liquid was easily biodegradable. In addition, the volume of the sludge dewatering liquid was small, which could be directly discharged to the wastewater treatment plant.
更新日期/Last Update: 2022-06-01
